Deo's Sandwich Shop

428 Grotto St, Eureka

Routine Inspection

ROACHY SAYS:

“Take a victory lap, Deo's Sandwich Shop! In the race that is maintaining a clean and healthy establishment you've earned Roachy's gold medal! Eat here today, everyone!!”

CP - Change of Ownership

ROACHY SAYS:

“Take a victory lap, Deo's Sandwich Shop! In the race that is maintaining a clean and healthy establishment you've earned Roachy's gold medal! Eat here today, everyone!!”

Routine Inspection
08. Proper hot and cold holding temperatures.

Conditions Observed: Measured several potentially hazardous food items holding in bottom portion of sandwich prep table >41F. Adjust/service/repair sandwich prep table to hold cold potentially hazardous foods at/below 41F at all times.

ROACHY SAYS:

“Except during preparation, cooking, cooling, transportation to or from a retail food facility for a period of less than thirty minutes, when time is used as the public health control, or as otherwise specified, potentially hazardous foods shall be maintained at or below 41F or at or above 135F. The following foods may be held at or below 45F: raw shell eggs, unshucked live molluscan shellfish, pasteurized milk and pasteurized milk products in original sealed containers, potentially hazardous foods held during transportation. Potentially hazardous foods held for dispensing in serving lines and salad bars may be held at 45F, not to exceed 12 hours in a 24 hour period, if unused portions are discarded. Food preparation shall not exceed two cumulative hours without a return to the required holding temperatures. (113996, 113998, 114037, 114343(a))”

Routine Inspection
44. Premises; personal/cleaning items; vermin-proofing.

Conditions Observed: Observed front door propped open over the duration of the inspection. The facility must remain vermin proof at all times. Keep door closed, or install a screen to prevent entrance or harborage of animals, birds and vermin, including but not limited to insects and rodents.

ROACHY SAYS:

“All premises of a food facility shall be kept clean, fully operative, and in good repair. The premise of a food facility shall be free of litter and items unnecessary to the operation of the facility. Areas designated for employees to eat and drink shall be located so that food, clean equipent and utensils, linens, and single-use articles are protected from contamination. Personal items shall be stored in a designated area to prevent contamination of food or utensils. Food prep sinks, warewashing sinks, and handwashing sinks shall not be used for the cleaning or maintenance of tools or cleaning supplies or to dispose of mop water and similar liquid wastes. A dedicated janitorial sink with a drain shall be provided and conveniently located. A separate room, area, or cabinet shall be provided for cleaning supplies. The facility shall be kept vermin proof. Insect electrocution devices shall retain the insect within the device and shall not be located over food or utensil handling areas. (114123, 114143(a, b), 114256, 114256.1, 114256.2, 114256.4, 114257, 114257.1, 114259, 114259.2, 114259.3, 114279, 114281, 114282)”

Routine Inspection
08. Proper hot and cold holding temperatures.

Conditions Observed: Measured tuna salad and egg salad 44.5F with probe thermometer in 2 door under counter refrigerator. Adjust/repair/replace this unit to hold cold potentially hazardous foods at or below 41F at all times.

ROACHY SAYS:

“Except during preparation, cooking, cooling, transportation to or from a retail food facility for a period of less than thirty minutes, when time is used as the public health control, or as otherwise specified, potentially hazardous foods shall be maintained at or below 41F or at or above 135F. The following foods may be held at or below 45F: raw shell eggs, unshucked live molluscan shellfish, pasteurized milk and pasteurized milk products in original sealed containers, potentially hazardous foods held during transportation. Potentially hazardous foods held for dispensing in serving lines and salad bars may be held at 45F, not to exceed 12 hours in a 24 hour period, if unused portions are discarded. Food preparation shall not exceed two cumulative hours without a return to the required holding temperatures. (113996, 113998, 114037, 114343(a))”

28. Food separated and protected.

Conditions Observed: Observed raw shell eggs stored over lunch meat in True under counter refrigerator. Store raw potentially hazardous foods under ready-to-eat foods to prevent cross-contamination.

ROACHY SAYS:

“Food shall be protected from contamination during transportation, storage, preparation, holding, and display. Adequate and suitable counter space shall be provided for all food preparation. Food preparation shall be conducted wthin an approved food compartment or fully enclosed food facility. Open-air barbecues shall be separated from public access. (113984(a-f), 113986, 114060, 114067(a,d,e,j), 114069(a, c, d), 114077, 114089.1(c), 114143(c,e))”

44. Premises; personal/cleaning items; vermin-proofing.

Conditions Observed: Observed front door propped open during the inspection. The facility is to remain vermin proof at all times. Keep door closed at all times, or install a screen to prevent entrance or harborage of animals, birds, and vermin, including but not limited to insects and rodents.

ROACHY SAYS:

“All premises of a food facility shall be kept clean, fully operative, and in good repair. The premise of a food facility shall be free of litter and items unnecessary to the operation of the facility. Areas designated for employees to eat and drink shall be located so that food, clean equipent and utensils, linens, and single-use articles are protected from contamination. Personal items shall be stored in a designated area to prevent contamination of food or utensils. Food prep sinks, warewashing sinks, and handwashing sinks shall not be used for the cleaning or maintenance of tools or cleaning supplies or to dispose of mop water and similar liquid wastes. A dedicated janitorial sink with a drain shall be provided and conveniently located. A separate room, area, or cabinet shall be provided for cleaning supplies. The facility shall be kept vermin proof. Insect electrocution devices shall retain the insect within the device and shall not be located over food or utensil handling areas. (114123, 114143(a, b), 114256, 114256.1, 114256.2, 114256.4, 114257, 114257.1, 114259, 114259.2, 114259.3, 114279, 114281, 114282)”

Routine Inspection
08. Proper hot and cold holding temperatures.

Conditions Observed: Observed container of mayonnaise held out of temperature control. Once a container of mayonnaise is opened, it shall be held at or below 41F at all times. Operator discarded mayonnaise that was held out of temperature control, thank you for correcting this major violation.

ROACHY SAYS:

“Except during preparation, cooking, cooling, transportation to or from a retail food facility for a period of less than thirty minutes, when time is used as the public health control, or as otherwise specified, potentially hazardous foods shall be maintained at or below 41F or at or above 135F. The following foods may be held at or below 45F: raw shell eggs, unshucked live molluscan shellfish, pasteurized milk and pasteurized milk products in original sealed containers, potentially hazardous foods held during transportation. Potentially hazardous foods held for dispensing in serving lines and salad bars may be held at 45F, not to exceed 12 hours in a 24 hour period, if unused portions are discarded. Food preparation shall not exceed two cumulative hours without a return to the required holding temperatures. (113996, 113998, 114037, 114343(a))”

12. Proper reheating procedures for hot holding.

Conditions Observed: Observed facility reheating frozen soup in original packaging in the microwave. Per manufacturer instructions on the soup, the soup shall remain frozen until reheated with hot water in the soup warmer. Instructed operator to discard microwaved soup and follow manufacturer’s instructions. Observed frozen soup, mixed with hot water, reheating in soup warmer. Use a thermometer to verify the soup reaches 170F - 180F within 2 hours prior to serving. Then hot hold between 150F - 160F (manufacturer instructions). Thank you for correcting this major violation.

ROACHY SAYS:

“Potentinally hazardous food that is cooked, cooled, and reheated for hot holding shall be heated to a temperature of 165F for 15 seconds. Cooked and refrigerated food that is prepared for immediate service in response to an individual consumer order may be served at any temperature. Reheating for hot holding shall be done rapidly, and the time between 41F and 165F shall not exceed two hours. Potentinally hazardous food reheated in a microwave oven for hot holding shall be rotated or stirred midway during cooking, covered to retain surface moisture, be reheated to 165F in all parts of the food, and stand covered for at least two minutes after reheating. Ready-to-eat food taken from a commercailly processed hermetically sealed container or from an intact package from a food processing plant shall be heated to a temperature of 135F for hot holding. (114014, 114016)”

31. Food storage; food storage containers identified.

Conditions Observed: Observed box of chips on the floor in dining area and condiments on the floor in the kitchen. Store foods at least 6 inches above the floor to protect from contamination or vermin attraction.

ROACHY SAYS:

“Adequate and suitable space shall be provided for the storage of food. Food shall be protected from contamination by storing the food in a clean, dry location, where it is not exposed to splash, dust, vermin, or other forms of contamination or adulteration, and at least six inches above the floor. Food shall not be stored in any of the following ways: in locker rooms, toilet rooms, dressing rooms, refuse rooms, mechanical rooms, under sewer lines that are not shielded to intercept potential drips, under leaking water lines, including leaking automatic fire sprinklers heads, or under lines on which water has condensated, under open stairwells or under sources of contamination. Working containers holding food or food ingredients that are removed from their original packages for use in the food facility shall be identified with the common name of the food. Non-prepackaged food may not be stored in direct contact with undrained ice. Products that are held by the permit holder for credit, redemption, or return to the distributor, such as damaged, spoiled, or recalled products shall be segregated and held in designated areas that are separated from food, equipment, utensils, linens, and single-use articles. (114047, 141049, 114051, 114053, 114055, 114067(h), 114069(b))”

Routine Inspection
08. Proper hot and cold holding temperatures.

Conditions Observed: Measured clam chowder 132.5F with probe thermometer in hot hold unit. Ensure the soup is hot held at or above 135F at all times. Obtain a stem thermometer for verification. It is the end of the day and operator agreed to discard what is left of the soup. This minor violation was corrected on site, thank you! Observed open containers of jalapenos and pepperoncinis held out of temperature control. Manufacturer specifies “refrigerate after opening” on the container. Once you open a container of jalpenos and pepperoncinis, it shall be held at or below 41F at all times. The remaining jalapenos and pepperoncinis were discarded. This major violation was corrected on site, thank you!

ROACHY SAYS:

“Except during preparation, cooking, cooling, transportation to or from a retail food facility for a period of less than thirty minutes, when time is used as the public health control, or as otherwise specified, potentially hazardous foods shall be maintained at or below 41F or at or above 135F. The following foods may be held at or below 45F: raw shell eggs, unshucked live molluscan shellfish, pasteurized milk and pasteurized milk products in original sealed containers, potentially hazardous foods held during transportation. Potentially hazardous foods held for dispensing in serving lines and salad bars may be held at 45F, not to exceed 12 hours in a 24 hour period, if unused portions are discarded. Food preparation shall not exceed two cumulative hours without a return to the required holding temperatures. (113996, 113998, 114037, 114343(a))”

28. Food separated and protected.

Conditions Observed: Observed raw potentially hazardous foods (shell eggs) stored over ready-to eat lunch meat in True under counter refrigerator. Store raw potentially hazardous foods under ready-to-eat foods to protect ready-to-eat foods from cross-contamination.

ROACHY SAYS:

“Food shall be protected from contamination during transportation, storage, preparation, holding, and display. Adequate and suitable counter space shall be provided for all food preparation. Food preparation shall be conducted wthin an approved food compartment or fully enclosed food facility. Open-air barbecues shall be separated from public access. (113984(a-f), 113986, 114060, 114067(a,d,e,j), 114069(a, c, d), 114077, 114089.1(c), 114143(c,e))”

34. Non-food-contact surfaces clean.

Conditions Observed: Observed debris and mold like substance in floor sink (near handwash sink). Clean non-food contact surfaces of equipment regularly to prevent buildup and/or mold growth.

ROACHY SAYS:

“Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris. (114115(b))”

© 2021 Lost Coast Communications Contact: news@lostcoastoutpost.com.