Henderson Center Fresh Freeze

3023 F St, Eureka
Routine Inspection
12. Proper reheating procedures for hot holding.

Conditions Observed: Measured chili 115F reheating in the food warmer. Potentially hazardous foods must reheated within 2 hours to 165F for 15 seconds. Reheat chili in the microwave or in a double broiler on the flat grill to at least 165F prior to hot holding in the food warmer. Employee removed chili from the food warmer and reheated it in the microwave until it reached at least 165F for 15 seconds. This major violation was corrected.

ROACHY SAYS:

“Potentinally hazardous food that is cooked, cooled, and reheated for hot holding shall be heated to a temperature of 165F for 15 seconds. Cooked and refrigerated food that is prepared for immediate service in response to an individual consumer order may be served at any temperature. Reheating for hot holding shall be done rapidly, and the time between 41F and 165F shall not exceed two hours. Potentinally hazardous food reheated in a microwave oven for hot holding shall be rotated or stirred midway during cooking, covered to retain surface moisture, be reheated to 165F in all parts of the food, and stand covered for at least two minutes after reheating. Ready-to-eat food taken from a commercailly processed hermetically sealed container or from an intact package from a food processing plant shall be heated to a temperature of 135F for hot holding. (114014, 114016)”

37. Equipment, utensils and linens: storage and use.

Conditions Observed: Observed utensil handle stored in direct contact with Oreo cookie pieces in bulk food container on ice cream side of the facility. Observed utensil handle fully submerged in bulk corn dog (dry) batter mix. Store utensils with handles facing up out of contact with food, or no longer store utensils in bulk food containers to prevent cross-contamination.

ROACHY SAYS:

“Clean equipment, utensils, linens, and single-use articles shall be stored at least six inches above the floor in an approved location within the fully enclosed permitted food facility. Clean equipment, utensils, linens, and single-use articles shall not be exposed to splash, dust, vermin, or other forms of contamination. Non-food items shall be stored and displayed separate from food and food-contact surfaces. During pauses in food preparation utensils shall be stored with handles above the top of the food, on a clean sanitized surface, in running water, or in water that is at least 135øF. Single-use articles and multiservice utensils shall be handled, displayed, and dispensed so that contamination of food and lip-contact surfaces is prevented. Extra preset tableware shall be removed when a consumer is seated or cleaned and sanitized before further use. Pressurized cylinders shall be securely fastened to rigid structure. Linens must be free of food residue and soil and be laundered as required. (114074, 114075(a,b,d,e), 114081, 114119, 114121, 114161, 114172, 114178, 114179, 114083, 114185, 114185.2, 114185.3, 114185.4, 114185.5)”

40. Wiping cloths: properly used and stored.

Conditions Observed: Observed wet wiping cloth stored on stainless steel counter without sanitizer solution. You may use a wet wiping cloth once and then launder it, or use it multiple times if held in an approved sanitizer solution. Manager provided bucket with QT sanitizer measuring 200PPM for wiping cloths. This minor violation was corrected. Please set-up sanitizer buckets prior to conducting food prep; change sanitizer frequently when it becomes visibly soiled or falls below the required concentration; use test strips to verify.

ROACHY SAYS:

“Wiping cloths used to clean food spills shall be used only once or stored in a sanitizing solution of an approved concentration as specified in section 114099.6. Dry or wet cloths that are used with raw foods of animal origin shall be kept separate from cloths used for other purposes, cloths that come into contact with raw foods of animal origin shall be kept in a separate sanitizing solution. Wiping cloths shall be free of food debris and visible soil. Working containers of sanitizing solutions for storage of in-use wiping cloths shall be used in a manner to prevent contamination of food, equipment, utensils, linens, or single-use articles. Wet wiping cloths shall be laundered daily. Dry wiping cloths shall be laundered as necessary to prevent contamination of food and clean serving utensils. (114135, 114185.1, 114185.3(d-e))”

Routine Inspection

ROACHY SAYS:

“Huzzah! This establishment has successfully impressed the government! Kudos, Henderson Center Fresh Freeze!!”

Routine Inspection

ROACHY SAYS:

“Wow! Roachy can see himself in your butterknives! Way to go, Henderson Center Fresh Freeze!!”

Routine Inspection

ROACHY SAYS:

“Wow! Roachy can see himself in your butterknives! Way to go, Henderson Center Fresh Freeze!!”

Routine Inspection
22. Hot and Cold Water Available

Conditions Observed: Hot water measured 117F at 3 compartment sink. Adjust/repair water heater to provide hot water at or above 120F at all mixing faucets at all times.

ROACHY SAYS:

“An adequate, protected, pressurized, approved potable supply of hot and cold water shall be provided at all times. Hot water shall be supplied at a minimum temperature of 120F when measured from the faucet. The temperature of water provided to handwashing facilities shall be at least 100F. Handwashing facilities equipped with non-adjustable faucets shall have their temperature set between 100F and 108F. Hot water shall be provided at the food preparation sink and janitorial sink. (113953(c), 114099.2(b), 114163(a)(3), 114189, 114192, 114192.1, 114195)”

28. Food separated and protected.

Conditions Observed: Observed raw ground beef stored over raw pork in walk-in refrigerator. Store raw potentially hazardous foods from animal origin based on final internal cooking temperatures to prevent cross-contamination. The final internal cooking temperature for pork is 145F and the final internal cooking temperature for ground beef is 155F; Store raw ground beef under raw pork to prevent cross-contamination. Operator corrected refrigerator food storage order, thank you.

ROACHY SAYS:

“Food shall be protected from contamination during transportation, storage, preparation, holding, and display. Adequate and suitable counter space shall be provided for all food preparation. Food preparation shall be conducted wthin an approved food compartment or fully enclosed food facility. Open-air barbecues shall be separated from public access. (113984(a-f), 113986, 114060, 114067(a,d,e,j), 114069(a, c, d), 114077, 114089.1(c), 114143(c,e))”

Routine Inspection
06. Hands clean and properly washed; gloves used properly.

Conditions Observed: Observed employee handle cash and credit cards then proceed to make ice cream cones and milkshakes without required handwashing between tasks. Handwashing is required after handling cash, credit/debit cards and prior to conducting food prep/service. This was discussed during the routine inspection/complaint investigation conducted on 3/14/19. Consider staffing more than one employee on the ice cream side of the facility during busy hours so one employee can cashier and another employee can serve ice cream. This is a major violation that will require a reinspection on or after 7/29/19. You may hold an employee training on handwashing and submit employee training sign-in sheet to this office by 7/29/19 in place of a reinspection.

ROACHY SAYS:

“Food employees shall minimize bare hand and arm contact with nonprepackaged food that is in ready to eat form. Whenever gloves are worn, they shall be changed, replaced, or washed as often as handwashing is required. Single-use gloves shall not be washed. Employees shall wash their hands in the following situations: immediately before engaging in food preparation including working with nonprepackaged food, clean equipment and utensils and unwrapped single-use food containers and utensils; after touching bare human body parts other than clean hands and clean exposed portions of arms; after using the toilet room; after caring for or handling any animal; after coughing, sneezing, using a handkerchief or disposable tissue, using tobacco, eating or drinking; after handling soiled equipment or utensils; during food preparation, as often as necessary to remove soil and contamination and to prevent cross-contamination when changing tasks; when switching from working with raw food and working with ready-to-eat foods; before initially donning gloves for working with food; before dispensing or serving food handling clean tableware and serving utensils in the food service area; after engaging in other activities that contaminate the hands. (113952, 113953.3, 113953.4, 113961, 113968, 113973)”

08. Proper hot and cold holding temperatures.

Conditions Observed: Measured ranch dressing 50.5F and 1000 island dressing 51F with probe thermometer in ice bath adjacent to cash register. Recommend using metal containers to conduct colder temperatures to foods held in ice bath as plastic is an insulator. Recommend fully submerging potentially hazardous foods in ice bath to hold at or below 41F at all times. Manager set-up another ice bath and fully submerged ranch and 1000 island dressing. This major violation was corrected on site.

ROACHY SAYS:

“Except during preparation, cooking, cooling, transportation to or from a retail food facility for a period of less than thirty minutes, when time is used as the public health control, or as otherwise specified, potentially hazardous foods shall be maintained at or below 41F or at or above 135F. The following foods may be held at or below 45F: raw shell eggs, unshucked live molluscan shellfish, pasteurized milk and pasteurized milk products in original sealed containers, potentially hazardous foods held during transportation. Potentially hazardous foods held for dispensing in serving lines and salad bars may be held at 45F, not to exceed 12 hours in a 24 hour period, if unused portions are discarded. Food preparation shall not exceed two cumulative hours without a return to the required holding temperatures. (113996, 113998, 114037, 114343(a))”

30. Toxic substances properly identified, stored, used.

Conditions Observed: Observed unlabeled chemical spray bottle on ice cream side of facility. Label all chemicals when taken out of original manufacturer’s packaging for safety.

ROACHY SAYS:

“Only those insecticides, rodenticides, and other pesticides that are necessary, bear a legible manufacturer's label, and are specifically approved for use in a food facility may be used in a food facility in accordance with the manufacturer's instructions. Containers used for storing poisonous or toxic materiails such as cleaners and sanitizers taken from bulk supplies shall be clearly and individually identified with the common name of the material. Poisonous or toxic materials shall be stored or displayed to prevent contamination of food, equipment, utensils, linens, and single-use articles. (114254, 114254.1, 114254.2)”

34. Non-food-contact surfaces clean.

Conditions Observed: Observed buildup on non-food contact surface of ice tea machine. Clean non-food contact surfaces of equipment regularly to prevent buildup.

ROACHY SAYS:

“Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris. (114115(b))”

37. Equipment, utensils and linens: storage and use.

Conditions Observed: Observed utensil handle in direct contact with Oreo cookie topping on ice cream side of facility. Store utensils with handles facing up out of contact with food to prevent cross-contamination.

ROACHY SAYS:

“Clean equipment, utensils, linens, and single-use articles shall be stored at least six inches above the floor in an approved location within the fully enclosed permitted food facility. Clean equipment, utensils, linens, and single-use articles shall not be exposed to splash, dust, vermin, or other forms of contamination. Non-food items shall be stored and displayed separate from food and food-contact surfaces. During pauses in food preparation utensils shall be stored with handles above the top of the food, on a clean sanitized surface, in running water, or in water that is at least 135øF. Single-use articles and multiservice utensils shall be handled, displayed, and dispensed so that contamination of food and lip-contact surfaces is prevented. Extra preset tableware shall be removed when a consumer is seated or cleaned and sanitized before further use. Pressurized cylinders shall be securely fastened to rigid structure. Linens must be free of food residue and soil and be laundered as required. (114074, 114075(a,b,d,e), 114081, 114119, 114121, 114161, 114172, 114178, 114179, 114083, 114185, 114185.2, 114185.3, 114185.4, 114185.5)”

44. Premises; personal/cleaning items; vermin-proofing.

Conditions Observed: Observed dining room door propped open during the inspection. Observed order window of main facility lacking a screen. The facility must remain vermin proof at all times. Keep all doors closed or install screens to prevent entrance or harborage of animals, birds, or vermin, including but not limited to, insects and rodents.

ROACHY SAYS:

“All premises of a food facility shall be kept clean, fully operative, and in good repair. The premise of a food facility shall be free of litter and items unnecessary to the operation of the facility. Areas designated for employees to eat and drink shall be located so that food, clean equipent and utensils, linens, and single-use articles are protected from contamination. Personal items shall be stored in a designated area to prevent contamination of food or utensils. Food prep sinks, warewashing sinks, and handwashing sinks shall not be used for the cleaning or maintenance of tools or cleaning supplies or to dispose of mop water and similar liquid wastes. A dedicated janitorial sink with a drain shall be provided and conveniently located. A separate room, area, or cabinet shall be provided for cleaning supplies. The facility shall be kept vermin proof. Insect electrocution devices shall retain the insect within the device and shall not be located over food or utensil handling areas. (114123, 114143(a, b), 114256, 114256.1, 114256.2, 114256.4, 114257, 114257.1, 114259, 114259.2, 114259.3, 114279, 114281, 114282)”

45. Floor, walls, and ceilings: built, maintained, clean.

Conditions Observed: Observed food debris on kitchen ceiling. Clean impacted area to prevent buildup. Observed floors are failing throughout the facility. Install floors that are smooth, durable, nonabsorbent and easy to clean with minimum 3/8” radius coving that extends up the wall at least 4 inches. Submit spec sheets or floor samples to this office for approval prior to purchase and installation.

ROACHY SAYS:

“Food facilities shall be fully enclosed in a building consisting of permanent floors, walls, and an overhead structure that meets minimum standards. The walls and ceiling shall be smooth, durable, nonabsorbent, and easily cleanable. Flooring and base coving shall be smooth, durable, and made of approved nonabsorbent material that is easily cleanable. Floor surfaces shall be coved at the juncture of the floor and wall with a 3/8 inch minimum radius and shall extend up the wall at least 4 inches. (114143(d), 114266, 114268, 114268.1, 114271, 114272)”

Routine Inspection
22. Hot and Cold Water Available

Conditions Observed: Measured hot water 114F with probe thermometer at 3 compartment sink. Adjust/repair/replace water heater to deliver hot water at or above 120F at all mixing faucets at all times.

ROACHY SAYS:

“An adequate, protected, pressurized, approved potable supply of hot and cold water shall be provided at all times. Hot water shall be supplied at a minimum temperature of 120F when measured from the faucet. The temperature of water provided to handwashing facilities shall be at least 100F. Handwashing facilities equipped with non-adjustable faucets shall have their temperature set between 100F and 108F. Hot water shall be provided at the food preparation sink and janitorial sink. (113953(c), 114099.2(b), 114163(a)(3), 114189, 114192, 114192.1, 114195)”

28. Food separated and protected.

Conditions Observed: Observed uncovered hot fudge and caramel in ice cream side of facility. Cover all foods to protect from contamination.

ROACHY SAYS:

“Food shall be protected from contamination during transportation, storage, preparation, holding, and display. Adequate and suitable counter space shall be provided for all food preparation. Food preparation shall be conducted wthin an approved food compartment or fully enclosed food facility. Open-air barbecues shall be separated from public access. (113984(a-f), 113986, 114060, 114067(a,d,e,j), 114069(a, c, d), 114077, 114089.1(c), 114143(c,e))”

34. Non-food-contact surfaces clean.

Conditions Observed: Observed grease accumulation on non-food contact surfaces of cookline equipment. Equipment shall be kept free of encrusted grease deposits and other soil accumulation. Observed dust accumulation on heat lamp, light fixtures, ventilation hood, and menu board. Clean impacted areas regularly to prevent grease and dust accumulation on non-food contact surfaces.

ROACHY SAYS:

“Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris. (114115(b))”

45. Floor, walls, and ceilings: built, maintained, clean.

Conditions Observed: Observed food debris on kitchen ceiling. Clean impacted area to prevent debris buildup. Observed floors have failed throughout the facility. Per Paula Hamilton, billing contact for Redwood Restaurants, the floors were to be replaced in the ice cream side of the facility this past February. Specification sheets must be submitted to this office for approval prior to purchase and installation of the new floors. Please submit spec sheets for approval.

ROACHY SAYS:

“Food facilities shall be fully enclosed in a building consisting of permanent floors, walls, and an overhead structure that meets minimum standards. The walls and ceiling shall be smooth, durable, nonabsorbent, and easily cleanable. Flooring and base coving shall be smooth, durable, and made of approved nonabsorbent material that is easily cleanable. Floor surfaces shall be coved at the juncture of the floor and wall with a 3/8 inch minimum radius and shall extend up the wall at least 4 inches. (114143(d), 114266, 114268, 114268.1, 114271, 114272)”

© 2024 Lost Coast Communications Contact: news@lostcoastoutpost.com.