Safeway #0793 Arcata

Food Est - Meat & Grocery - Full Prep
600 F St, Arcata

Routine Inspection
17. Compliance with shell stock tags, condition, display.

Conditions Observed: Observed shell stock tags lack an out date. Revise your shellstock record keeping system to include an out date (specify the dates of sale for each stock). See regulation description.

ROACHY SAYS:

“Shellstock shall be obtained in containers that bear legible source identification tags. A food facility shall ensure that shellstock from one tagged or labeled container are not commingled with shellstock from another container with different certification numbers. Shellstock tags shall remain attached to the container that they are received in until the container is empty. The identity of the source of the shellstock sold or served shall be maintained for 90 days from the dates of harvest by using an approved recordkeeping system that keeps the tags or labels in chronological order correlated to the date or dates the shellstock is sold or served. The source of the shellstock on display shall be identified. Shellstock that are portioned or prepackaged shall have a copy of the corresponding shellstock tag. Except in accordance with an approved HACCP plan, molluscan shellfish life-support system display tanks shall not be used to display shellfish that are offered for human consumption. (114039-114039.5)”

41. Plumbing: proper backflow devices.

Conditions Observed: Observed build-up, debris on black pipe above foods store in area between grocery aise 11 and 12 storage areas. Identify case of build-up and correct. Avoid storing food below impacted piping.

ROACHY SAYS:

“Steam tables, ice machines, ice bins, food preparation sinks, display cases, walk-in refrigeration units, and other similar equipment that discharge liquid waste shall drain into a floor sink with an air gap or other approved type of receptor. All plumbing and plumbing fixtures shall be installed in compliance with applicable local plumbing ordinances, maintained so as to prevent any contamination, kept clean, fully operative, and in good repair. The potable water supply shall be protected with a backflow or back siphonage protection device. Any hose used for potable water shall be of approved materials, labeled, properly stored, and used for no other purpose. Liquid drain lines shall not pass through an ice machine or an ice storage bin. (114171, 114190, 114192, 114193, 114193.1, 114199, 114201, 114269)”

Routine Inspection
07. Adequate handwash facilities supplied and accessible.

Conditions Observed: Observed meat department handwashing sink to be obstructed today. Employee moved brooms, dust pan, spray models to make sink accessible. COS. Keep handwashing unobstructed and accessible at all times.

ROACHY SAYS:

“Handwashing facilities shall be provided within or adjacent to toilet rooms, food preparation, and warewashing areas. Handwashing facilities shall be clean, unobstructed, and accessible at all times. Handwashing facilities shall be provided with soap and sanitary single use towels in approved dispensers. Dispensers shall be maintained in good repair. A handwashing facility shall not be used for purposes other than handwashing. (113953, 113953.1, 113953.2, 114067(f))”

36. Equipment / Utensils approved; installed, clean, good repair, capacity.

Conditions Observed: Encounter loud rattling noise from center of sandwich grab and go case near the deli today. Identify source of noise and correct. Maintain case to be in good working condition.

ROACHY SAYS:

“Utensils and equipment shall be kept fully operative and in good repair. All new and replacement equipment shall be properly installed and be certified or classified for sanitation by an ANSI accredited certification program. Electrical appliances must meet UL standards. Single-use articles shall not allow migration of deleterious substances or impart colors, odors, or tastes to food. Multi-use food contact surfaces must be smooth, free of breaks, chips, and similar imperfections; free of sharp internal angles, corners, and crevices; finished to have smooth welds and joints; be accessible for cleaning and inspection. Unless specified, wood and wood wicker may not be used as a food-contact surface. Unless specified, copper and copper alloys such as brass may not be used in contact with a food that has a pH below six or for a fitting between a backflow preventer and a carbonator. Beverage tubing and cold-plate beverage cooling devices cannot be installed in contact with stored ice intended to be used as food. Equipment that is not movable must be installed to allow for cleaning in place. Cutting or piercing parts of can openers must be readily removable. Facilities that wash, rinse, soak, thaw, or similarly prepare foods shall be provided with a approved food preparation sink. Reservoirs that supply water to produce foggers must be cleaned and maintained. Surfaces such as cutting blocks and boards that are subject to scratching and scoring shall be resurfaced or replaced if they can no longer be effectively cleaned and sanitized. (114130, 114130.1, 114130.2, 114130.3, 114130.4, 114130.5, 114130.6, 114132, 114133, 114137, 114139, 114153, 114163, 114165, 114167, 114169, 114175, 114177, 114180, 114182)”

41. Plumbing: proper backflow devices.

Conditions Observed: Observed leak from two sections of pipe below the two part sink in the meat department. Identify cause of leak and correct to eliminate free moisture. Observed leak from black overhead pipe above storage area between aisle 11 and aisle 12 storage areas. Per GM, a work order has been put in to repair the pipe. Eliminate leak; maintain storage areas dry and tidy.

ROACHY SAYS:

“Steam tables, ice machines, ice bins, food preparation sinks, display cases, walk-in refrigeration units, and other similar equipment that discharge liquid waste shall drain into a floor sink with an air gap or other approved type of receptor. All plumbing and plumbing fixtures shall be installed in compliance with applicable local plumbing ordinances, maintained so as to prevent any contamination, kept clean, fully operative, and in good repair. The potable water supply shall be protected with a backflow or back siphonage protection device. Any hose used for potable water shall be of approved materials, labeled, properly stored, and used for no other purpose. Liquid drain lines shall not pass through an ice machine or an ice storage bin. (114171, 114190, 114192, 114193, 114193.1, 114199, 114201, 114269)”

Routine Inspection
31. Food storage; food storage containers identified.

Conditions Observed: Observed cases of milk on the walkin floor. Observed boxed cereal (part of a display) in the floor. Store all foods at least 6 inches above the floor.

ROACHY SAYS:

“Adequate and suitable space shall be provided for the storage of food. Food shall be protected from contamination by storing the food in a clean, dry location, where it is not exposed to splash, dust, vermin, or other forms of contamination or adulteration, and at least six inches above the floor. Food shall not be stored in any of the following ways: in locker rooms, toilet rooms, dressing rooms, refuse rooms, mechanical rooms, under sewer lines that are not shielded to intercept potential drips, under leaking water lines, including leaking automatic fire sprinklers heads, or under lines on which water has condensated, under open stairwells or under sources of contamination. Working containers holding food or food ingredients that are removed from their original packages for use in the food facility shall be identified with the common name of the food. Non-prepackaged food may not be stored in direct contact with undrained ice. Products that are held by the permit holder for credit, redemption, or return to the distributor, such as damaged, spoiled, or recalled products shall be segregated and held in designated areas that are separated from food, equipment, utensils, linens, and single-use articles. (114047, 141049, 114051, 114053, 114055, 114067(h), 114069(b))”

36. Equipment / Utensils approved; installed, clean, good repair, capacity.

Conditions Observed: Observed build-up on scoop for bulk apricots. Observed build up in dispensers for some bulk nuts. Maintain clean bulk scoops and bins.

ROACHY SAYS:

“Utensils and equipment shall be kept fully operative and in good repair. All new and replacement equipment shall be properly installed and be certified or classified for sanitation by an ANSI accredited certification program. Electrical appliances must meet UL standards. Single-use articles shall not allow migration of deleterious substances or impart colors, odors, or tastes to food. Multi-use food contact surfaces must be smooth, free of breaks, chips, and similar imperfections; free of sharp internal angles, corners, and crevices; finished to have smooth welds and joints; be accessible for cleaning and inspection. Unless specified, wood and wood wicker may not be used as a food-contact surface. Unless specified, copper and copper alloys such as brass may not be used in contact with a food that has a pH below six or for a fitting between a backflow preventer and a carbonator. Beverage tubing and cold-plate beverage cooling devices cannot be installed in contact with stored ice intended to be used as food. Equipment that is not movable must be installed to allow for cleaning in place. Cutting or piercing parts of can openers must be readily removable. Facilities that wash, rinse, soak, thaw, or similarly prepare foods shall be provided with a approved food preparation sink. Reservoirs that supply water to produce foggers must be cleaned and maintained. Surfaces such as cutting blocks and boards that are subject to scratching and scoring shall be resurfaced or replaced if they can no longer be effectively cleaned and sanitized. (114130, 114130.1, 114130.2, 114130.3, 114130.4, 114130.5, 114130.6, 114132, 114133, 114137, 114139, 114153, 114163, 114165, 114167, 114169, 114175, 114177, 114180, 114182)”

39. Thermometers provided and accurate.

Conditions Observed: No thermometer in meat department display case. Provide an NSF approved cold-holding thermometer for this case.

ROACHY SAYS:

“An accurate easily readable metal probe thermometer suitable for measuring temperature of food shall be available to the food handler. Thermometers shall be calibrated in accordance with manufacturer's specifications as necessary to ensure their accuracy. A thermometer +/- 2 degrees F shall be provided for all refrigerators, hot and cold holding units, and high temperature warewashing machines. (114157, 114159)”

43. Toilet facilities: properly constructed, supplied, cleaned.

Conditions Observed: Observed sink, toilet, and floor around toilet need cleaning in men’s employee restroom. Maintain a clean and tidy restroom. Train staff to communicate when restrooms need cleaning.

ROACHY SAYS:

“Toilet facilities shall be maintained and kept clean. Toilet rooms shall be separated by a well-fitting, self-closing door. Toilet tissue shall be provided in a permanently installed dispenser at each toilet. (114250, 114250.1, 114276)”

Routine Inspection
06. Hands clean and properly washed; gloves used properly.

Conditions Observed: No paper towels at handwashing sink in meat cutting room. Employee refilled dispenser. COS. Keep paper towel dispenser stocked at all times.

ROACHY SAYS:

“Food employees shall minimize bare hand and arm contact with nonprepackaged food that is in ready to eat form. Whenever gloves are worn, they shall be changed, replaced, or washed as often as handwashing is required. Single-use gloves shall not be washed. Employees shall wash their hands in the following situations: immediately before engaging in food preparation including working with nonprepackaged food, clean equipment and utensils and unwrapped single-use food containers and utensils; after touching bare human body parts other than clean hands and clean exposed portions of arms; after using the toilet room; after caring for or handling any animal; after coughing, sneezing, using a handkerchief or disposable tissue, using tobacco, eating or drinking; after handling soiled equipment or utensils; during food preparation, as often as necessary to remove soil and contamination and to prevent cross-contamination when changing tasks; when switching from working with raw food and working with ready-to-eat foods; before initially donning gloves for working with food; before dispensing or serving food handling clean tableware and serving utensils in the food service area; after engaging in other activities that contaminate the hands. (113952, 113953.3, 113953.4, 113961, 113968, 113973)”

08. Proper hot and cold holding temperatures.

Conditions Observed: Measured minor temperature violations in the prepackaged soup unit (chicken noodle soup, 47 F; tomato basil, 44.5 F), in the reachin by the soda fountain (sous vide egg bite, 44.5; hardboiled egg in prepackaged salad, 46 F), in a bulk container of cut melon label 7/27 in the produce cutting room (melon 45 F, 46 F). Adjust/service/repair refrigeration units to cold-hold at 41 F or below. Request that persons servicing or repairing units clearly state deficienies and correct actions taken.

ROACHY SAYS:

“Except during preparation, cooking, cooling, transportation to or from a retail food facility for a period of less than thirty minutes, when time is used as the public health control, or as otherwise specified, potentially hazardous foods shall be maintained at or below 41F or at or above 135F. The following foods may be held at or below 45F: raw shell eggs, unshucked live molluscan shellfish, pasteurized milk and pasteurized milk products in original sealed containers, potentially hazardous foods held during transportation. Potentially hazardous foods held for dispensing in serving lines and salad bars may be held at 45F, not to exceed 12 hours in a 24 hour period, if unused portions are discarded. Food preparation shall not exceed two cumulative hours without a return to the required holding temperatures. (113996, 113998, 114037, 114343(a))”

15. Food contact surfaces: clean and sanitized.

Conditions Observed: Observed food debris on scoops (chocolate malt balls, yogurt cover pretzels) at the bulk bins; observed excessive build-up on interior of bulk nut dispensers. Wash, rinse, and sanitized impacted scoops. Remove debris from nut dispenser; clean and sanitze. All food contact surfaces shall be clean to the sight and clean to the touch.

ROACHY SAYS:

“Food-contact surfaces and utensils shall be clean to sight and touch. Food-contact surfaces and multiservice utensils shall be effectively washed, rinsed, and sanitized to remove or completely loosen soils by use of manual or mechanical methods. Precleaning may be required. Manual sanitization shall be accomplished during the final rinse by contact with solution containing 100 ppm available chlorine, 200 ppm quaternary ammonium, or another approved sanitizer. Mechanical sanitization shall be accomplished in the final rinse by achieving a utensil surface temperature of 160F or by contact with solution containing 50 ppm available chlorine, 200 ppm quaternary ammonium, or another approved sanitizer. After cleaning and sanitizing, equipment and utensils shall be air dried. Mechancial warewash machines must be approved and installed and operated according to manufacturer's specifications. Food contact surfaces, utensils, and equipment shall be cleaned and sanitized at the following times: before each use with different type of raw food of animal origin, when changing from raw food to ready to eat food, between uses with raw produce and potentially hazardous food, before using a thermometer, and any time during the operation when contamination may have occurred. Warewash sinks used to wash wiping cloths, wash produce, or thaw food must be cleaned and sanitized before and after these uses. Equipment, food contact surfaces, and utensils must be cleaned and sanitized throughout the day at least every four hours or as needed to prevent contamination. (114097, 114099.1, 114099.2, 114099.4, 114099.6, 114099.7, 114101, 114105, 114109, 114111, 114113, 114115(a,c), 114117, 114125(b), 114141)”

33. Food properly labeled and honestly presented.

Conditions Observed: Observed 10 cans of soy based, canned infant formula offered for sale after expiration (date printed on cans reads 1 July 2019). Assistant manager pulled cans from shelves. COS. Reviewed CalCode requirements for baby formula and foods. See regulation description above. Revise procedure to ensure that expired baby formula/foods are not offered for sale.

ROACHY SAYS:

“Any food is misbranded if its labeling is false or misleading, if it is offered for sale under the name of another food, or if it is an imitation of another food for which a definition and standard of identity has been established by regulation. A retail food facility shall not sell or offer for sale infant formula or baby food after the "use by" date. Food prepackaged in a food facility shall bear a label that complies with the labeling requirements prescribed by the Sherman Food, Drug, and Cosmetic Law. A franchise food chain with 20 or more stores must disclose calories, carbohydrates, saturated fat, and sodium for each standard menu item. Labeling is to be in the form of a brochure on the table, a menu next to each standard menu item, a menu under an index section separate from the listing of standard menu items, a menu insert, or a table tent on the table. (114087, 114088, 114089, 114089.1(a,b), 114090, 114093.1, 114094, 114094.5, 114377)”

34. Non-food-contact surfaces clean.

Conditions Observed: Observed green, moss-like build-up on baseboard in meat cutting room. Showed observations to employees. Remove; clean and sanitize. Observed excessive food debris in drawers below bulk bin. Remove debris.

ROACHY SAYS:

“Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris. (114115(b))”

41. Plumbing: proper backflow devices.

Conditions Observed: Observed leak at the handwashing sink in ladies employee restroom. Repair to eliminate source of leak.

ROACHY SAYS:

“Steam tables, ice machines, ice bins, food preparation sinks, display cases, walk-in refrigeration units, and other similar equipment that discharge liquid waste shall drain into a floor sink with an air gap or other approved type of receptor. All plumbing and plumbing fixtures shall be installed in compliance with applicable local plumbing ordinances, maintained so as to prevent any contamination, kept clean, fully operative, and in good repair. The potable water supply shall be protected with a backflow or back siphonage protection device. Any hose used for potable water shall be of approved materials, labeled, properly stored, and used for no other purpose. Liquid drain lines shall not pass through an ice machine or an ice storage bin. (114171, 114190, 114192, 114193, 114193.1, 114199, 114201, 114269)”

43. Toilet facilities: properly constructed, supplied, cleaned.

Conditions Observed: Observed doors to public restrooms to be open. Keep restrooms doors closed at all times or repair to be self-closing.

ROACHY SAYS:

“Toilet facilities shall be maintained and kept clean. Toilet rooms shall be separated by a well-fitting, self-closing door. Toilet tissue shall be provided in a permanently installed dispenser at each toilet. (114250, 114250.1, 114276)”

44. Premises; personal/cleaning items; vermin-proofing.

Conditions Observed: Observed a whole peach, mushroom, and similar produce scraps on floor around the composting bins. Keep floor clean and visible to prevent vermin activity.

ROACHY SAYS:

“All premises of a food facility shall be kept clean, fully operative, and in good repair. The premise of a food facility shall be free of litter and items unnecessary to the operation of the facility. Areas designated for employees to eat and drink shall be located so that food, clean equipent and utensils, linens, and single-use articles are protected from contamination. Personal items shall be stored in a designated area to prevent contamination of food or utensils. Food prep sinks, warewashing sinks, and handwashing sinks shall not be used for the cleaning or maintenance of tools or cleaning supplies or to dispose of mop water and similar liquid wastes. A dedicated janitorial sink with a drain shall be provided and conveniently located. A separate room, area, or cabinet shall be provided for cleaning supplies. The facility shall be kept vermin proof. Insect electrocution devices shall retain the insect within the device and shall not be located over food or utensil handling areas. (114123, 114143(a, b), 114256, 114256.1, 114256.2, 114256.4, 114257, 114257.1, 114259, 114259.2, 114259.3, 114279, 114281, 114282)”

45. Floor, walls, and ceilings: built, maintained, clean.

Conditions Observed: Observed excessive volume of water on produce walkin floor. This room appears to lack a floor drain. Identify and correct source of moisture. Consider other applicable regulations (i.e., OHSA).

ROACHY SAYS:

“Food facilities shall be fully enclosed in a building consisting of permanent floors, walls, and an overhead structure that meets minimum standards. The walls and ceiling shall be smooth, durable, nonabsorbent, and easily cleanable. Flooring and base coving shall be smooth, durable, and made of approved nonabsorbent material that is easily cleanable. Floor surfaces shall be coved at the juncture of the floor and wall with a 3/8 inch minimum radius and shall extend up the wall at least 4 inches. (114143(d), 114266, 114268, 114268.1, 114271, 114272)”

Routine Inspection
15. Food contact surfaces: clean and sanitized.

Conditions Observed: Measured QT at meat department 3part sink to be less than 200 PPM. Showed observations to Store Manager. Adjust/service/repair to deliver QT at 200 PPM. Wash dishes at deli 3part sink until QT delivery is correct. As discussed during the inspection, use test strips daily.

ROACHY SAYS:

“Food-contact surfaces and utensils shall be clean to sight and touch. Food-contact surfaces and multiservice utensils shall be effectively washed, rinsed, and sanitized to remove or completely loosen soils by use of manual or mechanical methods. Precleaning may be required. Manual sanitization shall be accomplished during the final rinse by contact with solution containing 100 ppm available chlorine, 200 ppm quaternary ammonium, or another approved sanitizer. Mechanical sanitization shall be accomplished in the final rinse by achieving a utensil surface temperature of 160F or by contact with solution containing 50 ppm available chlorine, 200 ppm quaternary ammonium, or another approved sanitizer. After cleaning and sanitizing, equipment and utensils shall be air dried. Mechancial warewash machines must be approved and installed and operated according to manufacturer's specifications. Food contact surfaces, utensils, and equipment shall be cleaned and sanitized at the following times: before each use with different type of raw food of animal origin, when changing from raw food to ready to eat food, between uses with raw produce and potentially hazardous food, before using a thermometer, and any time during the operation when contamination may have occurred. Warewash sinks used to wash wiping cloths, wash produce, or thaw food must be cleaned and sanitized before and after these uses. Equipment, food contact surfaces, and utensils must be cleaned and sanitized throughout the day at least every four hours or as needed to prevent contamination. (114097, 114099.1, 114099.2, 114099.4, 114099.6, 114099.7, 114101, 114105, 114109, 114111, 114113, 114115(a,c), 114117, 114125(b), 114141)”

33. Food properly labeled and honestly presented.

Conditions Observed: Observed two baby food items past expiration date (oatmeal, pouch) offered for sale. Manager removed items from shelf - COS. Increase frequency of date checking to avoid offering baby foods and formulas with expired best by dates.

ROACHY SAYS:

“Any food is misbranded if its labeling is false or misleading, if it is offered for sale under the name of another food, or if it is an imitation of another food for which a definition and standard of identity has been established by regulation. A retail food facility shall not sell or offer for sale infant formula or baby food after the "use by" date. Food prepackaged in a food facility shall bear a label that complies with the labeling requirements prescribed by the Sherman Food, Drug, and Cosmetic Law. A franchise food chain with 20 or more stores must disclose calories, carbohydrates, saturated fat, and sodium for each standard menu item. Labeling is to be in the form of a brochure on the table, a menu next to each standard menu item, a menu under an index section separate from the listing of standard menu items, a menu insert, or a table tent on the table. (114087, 114088, 114089, 114089.1(a,b), 114090, 114093.1, 114094, 114094.5, 114377)”

34. Non-food-contact surfaces clean.

Conditions Observed: Observed build-up/debris in the following areas: in the left bread drawer, in the bulk drawers, on the bottom shelves of the fresh pasta and veggie meat coolers; on the handle to the blast chiller, in the tracks for sliding doors on the deli display case. Remove debris; clean and sanitize.

ROACHY SAYS:

“Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris. (114115(b))”

© 2021 Lost Coast Communications Contact: news@lostcoastoutpost.com.